Custom Bid for Services - Internal inspection or Overhauling or Replacement of HV bushing or Rewi
Nuclear Power Corporation Of India Limited
Posted:
9 December 2024
Closed:
19 December 2024
GEM
GEM
Open Tender for Thorough inspection,Transportation charge,Lifting of transformer,Draining out the existing,Rewindin in PATNA, BIHAR
Progress
Issue26-Aug-2025, 12:09 pm
Technical29-08-2025 14:28:38
Financial
AwardCompleted
Quantity
824
Category
Rewinding of copper wound HT coils
Bid Type
Two Packet Bid
Categories
33
BUSHING PAINTS AND PRIMERS CONTROLLER SWITCHES TRANSITION METALS MEGA POWER PROJECT PAINTING ELECTRICAL SUBSTATION STATIC CONVERTERS CENTRE TABLE CHANGE OVER SWITCH CRUCIBLE FURNACES WASHERS PLAIN BEARING GAUGE SUB STATION MILITARY VEHICLE MODBUS TRANSPORTATION POWER CHAIN PULLEY SWITCH YARD PULLEY PRESS BEARINGS BUSHINGS AND GEARS PAINTS PRESS BOARD DIRECT TRANSFORMER TRANSFORMER OIL CHANNEL HARDWARE AND FASTENERS SUBSTATION SLEEVE BEARING SWITCH SUPPLY
A tender has been published for Bharat Sanchar Nigam Limited Portal(bsnl) Thorough inspection, Transportation charge, Lifting of transformer, Draining out the existing, Rewinding of copper wound LT coils, Rewinding of copper wound HT coils, Replacement of worn out, Replacement of LV bushing, Replacement of HV bushing, Reassembling and fitting, Replacement of existing faulty changeover switch, Heating of core and winding, Supplying and pouring, Painting of complete outer surface, Transportation charges for repaired, Re-installation of the above repaired in PATNA, BIHAR. Quantity: 824 by. Submission Deadline: 05-09-2025 13: 00: 00. Check eligibility and apply.
Documents 5
GeM-Bidding-8268775.pdf
Main Document
BOQ Document
BOQ
BOQ Document
BOQ
Buyer uploaded ATC document
ATC
GEM General Terms and Conditions Document
GEM_GENERAL_TERMS_AND_CONDITIONS
Past Similar Tenders
(Historical Results)
5 found
Repair of 1.5 Ton Split AC,Filling of Gas,Replacement of Capacitor,Repair of leakage in Cooling Pip
Indian Army
JODHPUR, RAJASTHAN
Posted:
12 June 2025
Closed:
3 July 2025
GEM
Repair Replacement of Solar Panel,Repair of Heating Rod,Repair of Copper Pipe,Overhauling of DG Set
Indian Army
Posted:
1 February 2025
Closed:
24 February 2025
GEM
Repair of 1.5 Ton Split AC,Filling of Gas,Replacement of capacitor,Repair of leakage in cooling pip
Indian Army
JODHPUR, RAJASTHAN
Posted:
10 January 2025
Closed:
31 January 2025
GEM
Repair of Tonbo Sight,Display replacement,Connector replacement,Calibration,Repair and Service Char
Indian Army
POONCH, JAMMU & KASHMIR
Posted:
19 September 2025
Closed:
29 September 2025
GEM
Tender Results
Loading results...
Bill of Quantities (BOQ)
16 Items
| Item # | Title | Description | Quantity | Unit | Consignee | Delivery (Days) |
|---|---|---|---|---|---|---|
| 1 | Thorough inspection | Testing and checking of the above 400 KVA copper wound transformer | 1 | job | mukul_anthony22 | 15 |
| 2 | Transportation charge | For transformer from BSNL Sanchar Sadan Budh Marg Patna to workshop at Patna | 1 | job | mukul_anthony22 | 15 |
| 3 | Lifting of transformer | Core and coil asssembly including removal of all the burnt HV and LV coils | 1 | job | mukul_anthony22 | 15 |
| 4 | Draining out the existing | Unserviceable transformer oil including cleaning the tank core assembly | 1 | job | mukul_anthony22 | 15 |
| 5 | Rewinding of copper wound LT coils | 50 Kg per coil for 3 coils with the matching of existing gauge with electrolytic high conductivity paper insulated | 150 | kg | mukul_anthony22 | 15 |
| 6 | Rewinding of copper wound HT coils | 13 Kg per coil for 12 coils with the matching of existing gauge with electrolytic high conductivity paper insulated | 156 | kg | mukul_anthony22 | 15 |
| 7 | Replacement of worn out | Gaskits crape tape cotton tape press board with new one | 1 | job | mukul_anthony22 | 15 |
| 8 | Replacement of LV bushing | 1point1 KV with studs Copper complete with nut washers oil seal and cap fitting | 4 | job | mukul_anthony22 | 15 |
| 9 | Replacement of HV bushing | 12 KV with studs Copper complete with nut washers oil seal and cap fitting | 3 | job | mukul_anthony22 | 15 |
| 10 | Reassembling and fitting | Rewinded transformer core with accessories bushing stud including paper and press boards | 1 | job | mukul_anthony22 | 15 |
| 11 | Replacement of existing faulty changeover switch | New 630 A On load 4 Pole changeover switch open execution type | 1 | nos | mukul_anthony22 | 15 |
| 12 | Heating of core and winding | Assembly in heat chamber in order to remove all traces of moisture from the insulations | 1 | job | mukul_anthony22 | 15 |
| 13 | Supplying and pouring | Transformer oil as per IS 335 duly filtered thoroughly before topping up oil | 500 | ltrs | mukul_anthony22 | 15 |
| 14 | Painting of complete outer surface | With epoxy primary coat & finish coat with enamel paint matching with existing colour | 1 | job | mukul_anthony22 | 15 |
| 15 | Transportation charges for repaired | Repaired 400 KVA transformer from workshop to Sanchar Sadan Budh Marg Patna | 1 | job | mukul_anthony22 | 15 |
| 16 | Re-installation of the above repaired | 400 KVA copper wound transformer on the existing plinth of the substation including shifting from campus to the plinth with the help of suitable man power chain pulley tools MS channel | 1 | job | mukul_anthony22 | 15 |
Required Documents
1
Experience Criteria
2
Past Performance
3
Bidder Turnover
4
Certificate (Requested in ATC)
5
OEM Authorization Certificate
6
OEM Annual Turnover
7
Additional Doc 1 (Requested in ATC)
8
Additional Doc 2 (Requested in ATC)
9
Additional Doc 3 (Requested in ATC)
10
Additional Doc 4 (Requested in ATC)
11
Compliance of BoQ specification and supporting document *In case any bidder is seeking exemption from Experience / Turnover Criteria
12
the supporting documents to prove his eligibility for exemption must be uploaded for evaluation by the buyer
Technical Results
| S.No | Seller | Item | Date | Status |
|---|---|---|---|---|
| 1 | COOL CONTROL Under PMA | - | 29-08-2025 14:28:38 | Qualified |
| 2 | pankaj electrical works Under PMA | - | 01-09-2025 13:03:32 | Disqualified |
| 3 | SINGH IMPRESSION Under PMA | - | 27-08-2025 16:49:14 | Qualified |
Financial Results
| Rank | Seller | Price | Item |
|---|---|---|---|
| L1 | SINGH IMPRESSION(MSE,MII)( MSE Social Category:General ) Under PMA | ₹5,08,399 | Item Categories : Thorough inspection,Transportation charge,Lifting of transformer,Draining out the existing,Rewindin |
| L2 | COOL CONTROL (MSE,MII)( MSE Social Category:OBC ) Under PMA | ₹5,08,473 | Item Categories : Thorough inspection,Transportation charge,Lifting of transformer,Draining out the existing,Rewindin |
Explore More Opportunities
Quick Access
Unlock Tender Documents
Sign up now to access all documents
Performance Analytics
7-metric analysis with year-wise breakdown
Competitor Intelligence
Multi-dimensional analysis across 6 parameters
Market Penetration
By department, ministry, geography & category
Historical Analysis
Complete tender history with results
Documents 5
GeM-Bidding-8268775.pdf
Main Document
BOQ Document
BOQ
BOQ Document
BOQ
Buyer uploaded ATC document
ATC
GEM General Terms and Conditions Document
GEM_GENERAL_TERMS_AND_CONDITIONS